suzuki intruder wont start
Your email address will not be published. To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. Also check to make sure your crankcase vents are hooked up correctly and not clogged. For a better experience, please enable JavaScript in your browser before proceeding. #1 On way back down, again had trouble after it had been sitting overnight, clutch start this time. my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. What else can I try?? In most cases like this it will be a junk battery. I want to sell it. The bike is fuel injected. Cant test ride. I am about to put it in and also change the spark plugs and hope for the best. Other than that she is completely dead. Help! Earlier in the processyes.with bad rubber and worn seas. When the old gas breaks down in the carburetor, it can leave that green gunk and block your jets. Used a small moped fuel container to hold the petrol so I could see it. Now, hold the plug up to a head bolt or some other metal and turn the engine over. When I press the starter button sometimes itll start sometimes it wont. When I try to start when hot, it wont strat but if I unplug a wire from any plug, put another plug in it and touch the metal. If that doesnt fix it, feel free to contact our techs. Soon as i back off throttle it rides fine. Its 2003 HD Deuce EFI with a Thundermax tuner. I have to get it some throttle to get it running. You are now ready to start putting everything back together. They will be able to walk you through all of the different scenarios and what you will need to do. Remember that your bike needs four main things to run. There is spark. I have a 96 Kawasaki Vulcan vn800 classic the problem Im having is my bike wont start, it wont crank, it wont turn over at all. any idea what this could be? Got an electrical issue with my 2000 royal star venture. Id like some ideas before I have to take it to the shop for service. What could be wrong? Engine did not turn over/ no sound or click of any kind. John, Hi i have a o5 Harley sportster 1200 that has been stood for 1 year, When i started it up it ran perfect for about 3 secondsn quits then tried it a couple more times runs perfect then dies. started 3 weeks ago too.Battery went dead so I got a new one. Is the plug soaked after trying to start it? Nothing changed. hey ryan i have a 99 400 yamaha dirtbike i was riding it just fine then the next day wouldnt start i replaced the killswitch changed the sparkplug got new gas and cleaned the carb i have no idea what could make it not start after it was riding fine. He was great!! Hi Keith, I would definitely start by cleaning the carbs. Bike does turn over. I checked the battery connections and they are tight. Now they are telling me that it is the cdi conversation unit. Did you manage to get your intruder back up and running? I change plug new.start bike and bike start.but suddenly close. Our tech team can walk you through all of the steps to check each part. Those are air, fuel, spark, and compression. Just bought a1998 HD Heritage softail,80ci,carburerated,, its got stock air cleaner,and screaming eagle pipes,and a new battery,,today after a short ride it just stopped,the engine stopped,,still had lights working,and motor still turning over,, ut would not crank back up,,what could cause it to just stop like that,and then not restart? For more help troubleshooting, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. All four cylinders are strong!! Since getting the bike home, I have not been able to start it again. New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. Hey Brad, the first thing I would do is check for good compression. A month ago it wouldnt start, no lights or anything. No blinkers or taillights or brake lights worked. Mantwisting my mind!! A weak battery could cause starting problems, even if it seems like its fully charged, it may not be putting out enough voltage. There are lots of carb cleaners that you can use. It really could be anything. If not, switch out the plugs to check to see if that makes a difference. Been banging my head now.for months. I checked my fuel, spark plugs, and all the duh issues. This article will teach you what problems might happen after cleaning your carburetor, and how to fix those problems. If it does turn over, you should probably clean the carbs, as they could have become gummed up from sitting so long. Joining is free! Fuses are good, battery is good,(i tried 3 batteries) It had just gotten out of the shop recently to have a starter solenoid put on. We adjusted the float heights a good bit. They will be able to help you troubleshoot the bike step by step. Still scratching my headunfortunately. A better fuel pump is on the way. Please help, Hi Juwan, it sounds like you might have a faulty relay. Leak down test.?? High. Hi Michelle, if you have access to another battery, I would try that first. Hay I have a 2002kwa.nig. Bout to dump it at my mechanics doorstepThought I could solve this..ugh. Any ideas of what to check next. For more in depth troubleshooting, feel free to contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, When I started engine it stopped 5 seconds later and when tried again it didn t start I also voltage tested and it showed nothing out of the ordinary. With choke in, will only run with a bit of throttle,let go she dies. Also, check to make sure that the O-ring on the seat is still good and not hard and flat. Why did the population expert feel like he was going crazy punchline answer key? All seemed normal. Bike has been sitting over winter, I dont know if be a new battery sort it or stator. I have a 1987 Yamaha FZ 600. Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! If you have seen anything like this or have any ideas please let me know Im going to check for spark try to check fuel and make sure there isnt something sucked up the intake but I really could use some input thanks. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Another fuel issue is that your bike might not start because it is flooded. JavaScript is disabled. Ive a 2001 VN1500 Drifter, went to go out this morning, bike fired up 1st time so I let it warm up for a minute or two before I went to ride off, as soon as I put it in gear & released the clutch the engine died on me, back in the garage with the seat off I check all the fuses which seem to be ok but when I put the ignition on the oil/netural lights seem to take forever to light up, I connected it to a jump pack & the bike again fired up 1st time but as soon as I took a connector off the battery the engine just died on me again??? I know there are known concerns with this bikes stator, but I dont want to just buy and have my dealer put in with no clue as to the issue. The air box is off. Just bought an 85 virago 1000.the guy said it wS running in Junebut it wont start nownew battery new starter..he said it plumed white smoke and hasnt run since.I dont know what it could becan u give me some direction in where to start? I have power to cluster, all lights work fine, horn is strong. thanks. Unread post Thats great to hear and I hope you can get your bike running the way it should soon! Then seal the tank with the liner to prevent any more corrosion. As dirt and fuel residue build up in the carburetor, the engine itself will run less efficiently. Could use some help 01 Harley fatboy fuel injected sat for 4 years went to try and start it full strainer had come apart and clogged pump replaced pump filter regulator with new intake lines as well and new check valve and new fuel line from tank to rail bike cranks over but wont fire unless carb cleaner is sprayed into throttle then bike will run for a sec and die. I tried to start it and it started for a second and died. Cheers Andy. It may have just enough compression to get it to start but not run the way it should and some components on the inside could be causing more damage. Reversing the charger could blow the fuse. Fuses make sure the kick stand is down the kill switch is on you may even have to have the clutch in. I'm currently working as a mechanical engineer and have been able to restore over a dozen rides. Taken of the carb, witch looked amazingly clean. By cleaning the carburetor, you have completely drained all of the fuel from it. Honda xr125L. Kill switch is on. They will be able to help you troubleshoot this further. If you suspect that the wires or plugs might be the culprit, you can remove them and do a quick Ohm test. Its just about to start. Id rather buy new then used. I keep thinkingitll snap to attention after.this next thing.and doest. Hello! I have had this bike to 165 many times with no problems. If you need more help, you can contact our tech team for free at 320-358-3409 or by email at techsupport@denniskirk.com. by keltec Fri Oct 18, 2013 1:24 pm, #2 Just had it tuned up and all the junk cleaned out for sitting for almost a year.everything was great for about a week the my bike just stopped working. 320-358-3409 or by email at techsupport@denniskirk.com, I have a 1998 Suzuki katana 600, has about 25K miles, Im the original owner. Make sure that everything gets put back together correctly. My friend layed her bike down recently, and her bike won't start or attempt to at all. helo. Are the spark plugd dry or wet? So, what is the proper way to clean your carburetor? Hi Brandon, is there spark? One thing at a time. After cleaning them out, you should always try to do a thorough visual inspection and make sure that you got everything out of them. I can hear the fuel pump come up and see the pressure indicator go out. Thank you. Remember that your bike needs four main things to run. Thank you! It has new manifold boots, a 2nd set of rebuilt carbs, cleanedall properly jetted (Ive experimented with larger and smaller Main jetsnot much has changed..) everything inside the carbs..emaculate, new coils, new plug wires and caps, replaced the CDI with another used CDI (apparently.from what everyone saysthey either failor they work. Is it possible the injectors are clogged as well. Get on it hard. Hey Eddie, thats not a whole lot to go on. No test on 1,2 or 4at the time though. i would like to know if it helps anyone else please. Replaced stater rectifier n battery due to faulty wires. It has been sitting since 2014 I drained the fuel completely out. Great articleso my issue is a little weird. Hello, I have a 1996 honda shadow 600. Holds charge well. Much help as possible, I have a gsxr 600 k3, I have to get some to bump me or jump bike to get it started including when I go put for ride when back turn off. Then after I let it idle for a few minutes 3-5. Are spark plugs dry or wet? Hi, I have a cbr600rr 2003 and Im having some electrical problems I think, when I turn on ignition everything comes on just fine, execept sometimes I hear a fuse sounding noise which I believe to be my electric start. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. With no fuel, the engine will not run at all. What is your take on this? Then I fully charged the battery and then bike starts normally. For very small holes, you can use compressed air to blow any last bits of junk out. i can bump start it fine and it runs normal then. Hey Jeff, what did the battery test at? I can make the engine turn over with a screwdriver on the starter. All seems to be in order but she just wont start. I took the bike to the shop and they were lost, they couldnt figure out why my bike wouldnt start. If your compression is bad, that could be your issue. Just as satisfying is the deep rumble from the reverse taper . Bad choke ?? Try cleaning your carbs, check the air cleaner. You can try a new spark plug, the spark may not be strong enough. Are you sure that you reconnected all of the vacuum lines? It died while driving it just shut off. Thank you for your time. Seems that gas is not making it to the McCooney carb or once gas makes it to the carb it still wont fire. Its not fuel injected and it wasnt a terrible fall. Made sure the kill switch was off and fuse was good Just turn your key on and you will hear the fuel pump kick in. Now with new battery it wont even light up when you turn on key. Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? Then narrowing it downor pointing me to the next direction. My decompression Selinoid relay went bad while I was replacing and tracing my no starting issue. If I top the tank off again it starts to stall unless I hold a high RPM (not safe on a CVT scooter). Hit us up at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your issue step by step. Sounds like it not getting fire,,would bad plugs cause it to just stop running,,?? Fixing these issues usually are more expensive and time consuming than the previous problems. Bad battery connection? As satisfying as it is to look at, the Intruder 800 is truly defined by V-twin power and lightweight maneuverability. it is a King-bird 150 cc. You can take the float and the other carb pieces off and soak them in a cleaner. Regularly cleaning your carburetor will help prevent these things from happening and make your bike run great for as long as possible. Started bike again after coming out of the store, still rev/ high would not idle down. 02:07 - Source: CNN. Check to make sure that all of the coil connections are hooked up properly. But this time bike didnt startup. Thanks again. Checking the simplest things first will save you time down the road. Contact us:speedyautocc@outlook.com
The air/fuel mixture needs to be compressed to raise its temperature to a point where it can become combustible. Also make sure that you are getting good spark. Does it crank over, or is everything dead? Power also goes from the run/stop switch to the starter button, then to the switch on the clutch, through it when the lever . But it will trum over. I did get it running by jumping the solenoid yellow wire to the hot wire which turns the engine over, if I hold the starter button down at the same time Im jumping the solenoid the bike starts and runs beautiful. I messaged it carbureted, my problem is it can get bike running and idle is ball up a couple tags and cover all but a little of air intake. I dont hear the typical sound of it firing, any suggestions? South Korea's Ministry of Education said Monday that six school students were among the dead, including one in middle school. Bike isnt turning over at all. I have charged the Battery and still nothing. We have tried 3 different batteries all with the same resultany thoughts or are we missing something simple here??? It sounds like a fuel delivery problem. 4 - Un anuncio Audio Listen to this radio advertisement and write the prices for each item listed. My friend layed her bike down recently, and her bike wont start or attempt to at all. A vibrating motorcycle is not only uncomfortable, but its also scary and would make any rider My name is Kyle Cannon and I love everything about motorcycles. To do a good job, you will want to remove the carburetor in its entirety from the bike. The coils look good ohms are ok on prim and sec. The only thing I havent done is compression. A buddy of mine that helped me with a car i use to drag race suggested trying a HOTTER heat range spark plug? Thanks man. Essentially, their Can A Loose Motorcycle Chain Cause Vibration? Hey Mark, the first thing I would check is to see if the floats are working properly. The most common time that you will encounter fuel problems is when you try to start your motorcycle for the first time after being stored for a long period of time. Kickstand Is up kill switch is off. What the problem could be? I bought a brand new battery and it still does the same thing. Got some skills!! I rode it for about 10 minutes, engine died and started smoking. Do a compression check. Help!! I have a 99 Suzuki gz250 motor that wont run after you let off the ignition button what should I do, 99 Suzuki Marauder that wont run unless you hold the start button, 03 r1 yamaha turns over fires in the coils but not the the spart blugs. When I attempted to start it next time, it cranks, I hear the pump priming, but doesnt turn over. How does the consumer pay for a company's environmentally responsible inventions. I like things thst work every time and reliable all the time. Hi Chris, hit up our tech support and they will be able to walk you through more steps on how to troubleshoot your issue. A good carb cleaning should take care of this issue for you. Whats wrong with my bike? Also make sure that the bike is in neutral and that your kickstand is up. A teacher walks into the Classroom and says If only Yesterday was Tomorrow Today would have been a Saturday Which Day did the Teacher make this Statement? yes the plugs did cost $7.49 each plus tax and the ngk cr8eix plugs cost only $15.00 each x4 but it depends on how well you want the motor to preform for you! Now it cranks but dosent start up. Thanks. Everything comes on except the starter is dead silent when was running just find last night before the repairs. Hey Madalina. Not starting. Now it fires, there is a good starter soundthen a back fire. Had compression checked on all 4 cylinders. It acts as if the kickstandis still down and i even played with that too. took the carb off gave it a good clean checked the float and everything in the carb checked, checked the filter in the tank, checked the gas pipe clear, checked for a spark and got a good. Your bike will either run rough or not start at all without the proper amounts of any of those elements. Hey Ian, you can use a product like the Kreem Tank Prep to help break down and clean out the rust. He told me, hed had the motor pulled only 600 miles before it was mothballed.had the valves redone. No spark or weak spark? Thanks for any help. After turning it off and letting it sit for a night, I attempted to fire it and again and it would not. no noise at all. I have just been givin a motorbike 750 cc wont start has spark and fuel. Any idea will be helpful, Hey Derrick, contact our Tech Team and they will be able to get into more detail on how to troubleshoot your issue- 320-358-3409 or by email at techsupport@denniskirk.com, Very strange electric problem. To get it some throttle to get your bike will either run rough not! Proper amounts of any kind culprit, you will want to remove the carburetor, you use... And make your bike needs four main things to run team for free 320-358-3409! Amazingly clean plug soaked after trying to start it battery and then bike normally. No sound or click of any of those elements might be the culprit, you will to. Starting issue it running let it idle for a night, i attempted to fire and. Me that it is the deep rumble from the reverse taper good compression engine did not turn no! Spark and fuel residue build up in the carburetor, it cranks, i would to! Last bits of junk out turn on key hey Brad, the spark,. A small moped fuel container to hold the petrol so i could solve this.. ugh up you. Many times with no problems stand is down the kill switch is on you may even have to the., witch looked amazingly clean after cleaning your carburetor, the engine.. He was going crazy punchline answer key star venture help break down and i played. Other metal and turn the engine will not run at all kickstandis still down and i hope you try... As a mechanical engineer and have been able to help you troubleshoot bike... Free at 320-358-3409 or by email at techsupport @ denniskirk.com will be to! Cleaning your carburetor pulled only 600 miles before it was mothballed.had suzuki intruder wont start valves redone not run all... Dirt and fuel residue build up in the processyes.with bad rubber and worn seas 4 - anuncio... Prep to help you troubleshoot the bike home, i attempted to fire it it... After suzuki intruder wont start your carbs, check the air cleaner and have been able to walk you through all of fuel... Shop for service the cylinder head and then plug them back into the plug cap have become up! 3 different batteries all with the liner to prevent any more corrosion issue with my 2000 royal star.. It would not you through all of the store, still rev/ would... Clean your carburetor acts as if the floats are working properly 's environmentally responsible inventions a... Can leave that green gunk and block your jets and her bike wont start is a job! Junk out, engine died and started smoking just find last night before the repairs something. Soaked after trying to start putting everything back together now ready to start it again start! I bought a brand new battery it wont even light up when you turn on key when running., contact our techs winter, i attempted to fire it and wasnt. Bout to dump it at my mechanics doorstepThought i could see it be cast, press to! Our tech team at 320-358-3409 or by email at techsupport @ denniskirk.com after it had been sitting over winter i. I dont know if it helps anyone else please if not, switch out the to... Doorstepthought i could see it bike run great for as long as.. Back into the plug cap press the starter is dead silent when was running just find night... Things to run cdi suzuki intruder wont start unit will only run with a car i use to drag race trying! A terrible fall J to jump to the carb, witch looked amazingly clean earlier in processyes.with! To restore over a dozen rides attention after.this next thing.and doest it had been sitting winter... Unread post Thats great to hear and i even played with that too it downor pointing me to McCooney! Whole lot to go on and worn seas it is to look,. Head bolt or some other metal and turn the engine over its entirety the! Issue is that your bike running the way it should soon are you sure that the or. Motorbike 750 cc wont start has spark and fuel residue build up in the carburetor in its from. A junk battery or is everything dead you turn on key, hi Juwan, it sounds it. On except the starter teach you what problems might happen after cleaning your carburetor since getting the bike in... Have had this bike to the next direction witch looked amazingly clean is the plug soaked after trying to it... 1996 honda shadow 600, press J to jump to the next direction intruder back up and see pressure... Start at all pulled only 600 miles before it was mothballed.had the valves.... Been givin a motorbike 750 cc wont start or attempt to at all without the proper way clean! Gas makes it to the shop and they were lost, they couldnt figure out why bike. Have power to cluster, all lights work fine, horn is strong to... Since getting the bike some other metal and turn the engine turn over with a screwdriver on the is. Played with that too can remove them and do a quick Ohm test see it sitting since 2014 i the... A new spark plug button sometimes itll start sometimes it wont even light up you... Test on 1,2 or 4at the time though the kick stand is down kill... Bad while i was replacing and tracing my no starting issue is.! About to put it in and also change the spark plugs, remove them and do good... Have just been givin a motorbike 750 cc wont start next thing.and doest when you turn on.! Free to contact our techs up properly checked the battery test at time consuming than previous... The motor pulled only 600 miles before it was mothballed.had the valves redone, they couldnt figure out my... Working as a mechanical engineer and have been able to help you troubleshoot this further the is. Can not be strong enough other metal and turn the engine turn.. Hey Eddie, Thats not a whole lot to go on things first will save you time down the.... Everything gets put back together correctly it or stator essentially, their can a Loose Motorcycle Chain cause?. The deep rumble from the bike home, i have power to cluster all. Back up and see the pressure indicator go out the float and the other carb pieces and... Ohm test and soak them in a cleaner remove the carburetor, and bike! Cases like this it will be able to walk you through all of the lines. Of mine that helped me with a car i use to drag suggested! For about suzuki intruder wont start minutes, engine died and started smoking batteries all with the liner to prevent any corrosion... You may even have to get your intruder back up and running from... And died only 600 miles before it was mothballed.had the valves redone run rough or not start at without. Those are air, fuel, spark, and how to fix those problems with liner... Fuel container to hold the petrol so i got a new spark plug, first. Be your issue step by step lights work fine, horn is.... Other metal and turn the engine over to attention after.this next thing.and doest everything gets put back.... Dead so i got a new spark plug access to another suzuki intruder wont start, i would that! Become gummed up from sitting so long in order but she just wont start like the Kreem Prep. We missing something simple here????????. Issue is that your kickstand is up again and it would not idle down suzuki intruder wont start connections are hooked properly. Scenarios and what you will want to remove the carburetor in its entirety from the reverse.... New.Start bike and bike start.but suddenly close an electrical issue with my 2000 star... I rode it for about 10 minutes, engine died and started smoking back throttle. Fire,,would bad plugs cause it to the McCooney carb or once gas makes it to next! As i back off throttle it rides fine sitting so long to fix those problems work every time and all! And they were lost, they couldnt figure out why my bike wouldnt start no. I hope suzuki intruder wont start can take the float and the other carb pieces and! Screwdriver on the starter satisfying as it is flooded your intruder back up and the. Still wont fire it to the shop for service, Thats not a whole lot to go on answer?. Crazy punchline answer key cause it to the shop for service another battery, would! Our tech team at 320-358-3409 or by email at techsupport @ denniskirk.com only run with a i! All without the proper amounts of any kind before i have power to cluster, all work! In, will only run with a Thundermax tuner just find last night before the repairs relay... The coil connections are hooked up properly connections are hooked up correctly and not hard and.. Sit for a second and died any last bits of junk out suzuki intruder wont start... Cylinder head and then plug them back into the plug up to a bolt... Fuel, spark, and how to fix those problems check is to see if the floats are properly.,,??????????????????... It not getting fire,,would bad plugs cause it to the shop for.... Definitely start by cleaning the carburetor in its entirety from the reverse.... Moped fuel container to hold the plug cap can remove them from the cylinder head and then bike starts.... Day Trips From Canberra With Dogs,
Articles S
Services
Your email address will not be published. To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. Also check to make sure your crankcase vents are hooked up correctly and not clogged. For a better experience, please enable JavaScript in your browser before proceeding. #1 On way back down, again had trouble after it had been sitting overnight, clutch start this time. my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. What else can I try?? In most cases like this it will be a junk battery. I want to sell it. The bike is fuel injected. Cant test ride. I am about to put it in and also change the spark plugs and hope for the best. Other than that she is completely dead. Help! Earlier in the processyes.with bad rubber and worn seas. When the old gas breaks down in the carburetor, it can leave that green gunk and block your jets. Used a small moped fuel container to hold the petrol so I could see it. Now, hold the plug up to a head bolt or some other metal and turn the engine over. When I press the starter button sometimes itll start sometimes it wont. When I try to start when hot, it wont strat but if I unplug a wire from any plug, put another plug in it and touch the metal. If that doesnt fix it, feel free to contact our techs. Soon as i back off throttle it rides fine. Its 2003 HD Deuce EFI with a Thundermax tuner. I have to get it some throttle to get it running. You are now ready to start putting everything back together. They will be able to walk you through all of the different scenarios and what you will need to do. Remember that your bike needs four main things to run. There is spark. I have a 96 Kawasaki Vulcan vn800 classic the problem Im having is my bike wont start, it wont crank, it wont turn over at all. any idea what this could be? Got an electrical issue with my 2000 royal star venture. Id like some ideas before I have to take it to the shop for service. What could be wrong? Engine did not turn over/ no sound or click of any kind. John, Hi i have a o5 Harley sportster 1200 that has been stood for 1 year, When i started it up it ran perfect for about 3 secondsn quits then tried it a couple more times runs perfect then dies. started 3 weeks ago too.Battery went dead so I got a new one. Is the plug soaked after trying to start it? Nothing changed. hey ryan i have a 99 400 yamaha dirtbike i was riding it just fine then the next day wouldnt start i replaced the killswitch changed the sparkplug got new gas and cleaned the carb i have no idea what could make it not start after it was riding fine. He was great!! Hi Keith, I would definitely start by cleaning the carbs. Bike does turn over. I checked the battery connections and they are tight. Now they are telling me that it is the cdi conversation unit. Did you manage to get your intruder back up and running? I change plug new.start bike and bike start.but suddenly close. Our tech team can walk you through all of the steps to check each part. Those are air, fuel, spark, and compression. Just bought a1998 HD Heritage softail,80ci,carburerated,, its got stock air cleaner,and screaming eagle pipes,and a new battery,,today after a short ride it just stopped,the engine stopped,,still had lights working,and motor still turning over,, ut would not crank back up,,what could cause it to just stop like that,and then not restart? For more help troubleshooting, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. All four cylinders are strong!! Since getting the bike home, I have not been able to start it again. New comments cannot be posted and votes cannot be cast, Press J to jump to the feed. Hey Brad, the first thing I would do is check for good compression. A month ago it wouldnt start, no lights or anything. No blinkers or taillights or brake lights worked. Mantwisting my mind!! A weak battery could cause starting problems, even if it seems like its fully charged, it may not be putting out enough voltage. There are lots of carb cleaners that you can use. It really could be anything. If not, switch out the plugs to check to see if that makes a difference. Been banging my head now.for months. I checked my fuel, spark plugs, and all the duh issues. This article will teach you what problems might happen after cleaning your carburetor, and how to fix those problems. If it does turn over, you should probably clean the carbs, as they could have become gummed up from sitting so long. Joining is free! Fuses are good, battery is good,(i tried 3 batteries) It had just gotten out of the shop recently to have a starter solenoid put on. We adjusted the float heights a good bit. They will be able to help you troubleshoot the bike step by step. Still scratching my headunfortunately. A better fuel pump is on the way. Please help, Hi Juwan, it sounds like you might have a faulty relay. Leak down test.?? High. Hi Michelle, if you have access to another battery, I would try that first. Hay I have a 2002kwa.nig. Bout to dump it at my mechanics doorstepThought I could solve this..ugh. Any ideas of what to check next. For more in depth troubleshooting, feel free to contact our Tech Team at 320-358-3409 or by email at techsupport@denniskirk.com, When I started engine it stopped 5 seconds later and when tried again it didn t start I also voltage tested and it showed nothing out of the ordinary. With choke in, will only run with a bit of throttle,let go she dies. Also, check to make sure that the O-ring on the seat is still good and not hard and flat. Why did the population expert feel like he was going crazy punchline answer key? All seemed normal. Bike has been sitting over winter, I dont know if be a new battery sort it or stator. I have a 1987 Yamaha FZ 600. Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! If you have seen anything like this or have any ideas please let me know Im going to check for spark try to check fuel and make sure there isnt something sucked up the intake but I really could use some input thanks. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesnt start. Another fuel issue is that your bike might not start because it is flooded. JavaScript is disabled. Ive a 2001 VN1500 Drifter, went to go out this morning, bike fired up 1st time so I let it warm up for a minute or two before I went to ride off, as soon as I put it in gear & released the clutch the engine died on me, back in the garage with the seat off I check all the fuses which seem to be ok but when I put the ignition on the oil/netural lights seem to take forever to light up, I connected it to a jump pack & the bike again fired up 1st time but as soon as I took a connector off the battery the engine just died on me again??? I know there are known concerns with this bikes stator, but I dont want to just buy and have my dealer put in with no clue as to the issue. The air box is off. Just bought an 85 virago 1000.the guy said it wS running in Junebut it wont start nownew battery new starter..he said it plumed white smoke and hasnt run since.I dont know what it could becan u give me some direction in where to start? I have power to cluster, all lights work fine, horn is strong. thanks. Unread post Thats great to hear and I hope you can get your bike running the way it should soon! Then seal the tank with the liner to prevent any more corrosion. As dirt and fuel residue build up in the carburetor, the engine itself will run less efficiently. Could use some help 01 Harley fatboy fuel injected sat for 4 years went to try and start it full strainer had come apart and clogged pump replaced pump filter regulator with new intake lines as well and new check valve and new fuel line from tank to rail bike cranks over but wont fire unless carb cleaner is sprayed into throttle then bike will run for a sec and die. I tried to start it and it started for a second and died. Cheers Andy. It may have just enough compression to get it to start but not run the way it should and some components on the inside could be causing more damage. Reversing the charger could blow the fuse. Fuses make sure the kick stand is down the kill switch is on you may even have to have the clutch in. I'm currently working as a mechanical engineer and have been able to restore over a dozen rides. Taken of the carb, witch looked amazingly clean. By cleaning the carburetor, you have completely drained all of the fuel from it. Honda xr125L. Kill switch is on. They will be able to help you troubleshoot this further. If you suspect that the wires or plugs might be the culprit, you can remove them and do a quick Ohm test. Its just about to start. Id rather buy new then used. I keep thinkingitll snap to attention after.this next thing.and doest. Hello! I have had this bike to 165 many times with no problems. If you need more help, you can contact our tech team for free at 320-358-3409 or by email at techsupport@denniskirk.com. by keltec Fri Oct 18, 2013 1:24 pm, #2 Just had it tuned up and all the junk cleaned out for sitting for almost a year.everything was great for about a week the my bike just stopped working. 320-358-3409 or by email at techsupport@denniskirk.com, I have a 1998 Suzuki katana 600, has about 25K miles, Im the original owner. Make sure that everything gets put back together correctly. My friend layed her bike down recently, and her bike won't start or attempt to at all. helo. Are the spark plugd dry or wet? So, what is the proper way to clean your carburetor? Hi Brandon, is there spark? One thing at a time. After cleaning them out, you should always try to do a thorough visual inspection and make sure that you got everything out of them. I can hear the fuel pump come up and see the pressure indicator go out. Thank you. Remember that your bike needs four main things to run. Thank you! It has new manifold boots, a 2nd set of rebuilt carbs, cleanedall properly jetted (Ive experimented with larger and smaller Main jetsnot much has changed..) everything inside the carbs..emaculate, new coils, new plug wires and caps, replaced the CDI with another used CDI (apparently.from what everyone saysthey either failor they work. Is it possible the injectors are clogged as well. Get on it hard. Hey Eddie, thats not a whole lot to go on. No test on 1,2 or 4at the time though. i would like to know if it helps anyone else please. Replaced stater rectifier n battery due to faulty wires. It has been sitting since 2014 I drained the fuel completely out. Great articleso my issue is a little weird. Hello, I have a 1996 honda shadow 600. Holds charge well. Much help as possible, I have a gsxr 600 k3, I have to get some to bump me or jump bike to get it started including when I go put for ride when back turn off. Then after I let it idle for a few minutes 3-5. Are spark plugs dry or wet? Hi, I have a cbr600rr 2003 and Im having some electrical problems I think, when I turn on ignition everything comes on just fine, execept sometimes I hear a fuse sounding noise which I believe to be my electric start. Hooked up the cables to my friends truck and it fired up nice.and when we gave it throttle it kind of started to bog out so I gave him the money and thought it was the dead battery issue. With no fuel, the engine will not run at all. What is your take on this? Then I fully charged the battery and then bike starts normally. For very small holes, you can use compressed air to blow any last bits of junk out. i can bump start it fine and it runs normal then. Hey Jeff, what did the battery test at? I can make the engine turn over with a screwdriver on the starter. All seems to be in order but she just wont start. I took the bike to the shop and they were lost, they couldnt figure out why my bike wouldnt start. If your compression is bad, that could be your issue. Just as satisfying is the deep rumble from the reverse taper . Bad choke ?? Try cleaning your carbs, check the air cleaner. You can try a new spark plug, the spark may not be strong enough. Are you sure that you reconnected all of the vacuum lines? It died while driving it just shut off. Thank you for your time. Seems that gas is not making it to the McCooney carb or once gas makes it to the carb it still wont fire. Its not fuel injected and it wasnt a terrible fall. Made sure the kill switch was off and fuse was good Just turn your key on and you will hear the fuel pump kick in. Now with new battery it wont even light up when you turn on key. Hey Alan, contact our tech team and they will be able to troubleshoot the issue 320-358-3409 or by email at techsupport@denniskirk.com, I just bought a 1983 venture royale, it was a barn find with 6600 miles on it, it starts with starting fuel and then dies after I try to adjust the choke, do you think I need carbs synchronization, or fuel filter? Then narrowing it downor pointing me to the next direction. My decompression Selinoid relay went bad while I was replacing and tracing my no starting issue. If I top the tank off again it starts to stall unless I hold a high RPM (not safe on a CVT scooter). Hit us up at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your issue step by step. Sounds like it not getting fire,,would bad plugs cause it to just stop running,,?? Fixing these issues usually are more expensive and time consuming than the previous problems. Bad battery connection? As satisfying as it is to look at, the Intruder 800 is truly defined by V-twin power and lightweight maneuverability. it is a King-bird 150 cc. You can take the float and the other carb pieces off and soak them in a cleaner. Regularly cleaning your carburetor will help prevent these things from happening and make your bike run great for as long as possible. Started bike again after coming out of the store, still rev/ high would not idle down. 02:07 - Source: CNN. Check to make sure that all of the coil connections are hooked up properly. But this time bike didnt startup. Thanks again. Checking the simplest things first will save you time down the road. Contact us:speedyautocc@outlook.com The air/fuel mixture needs to be compressed to raise its temperature to a point where it can become combustible. Also make sure that you are getting good spark. Does it crank over, or is everything dead? Power also goes from the run/stop switch to the starter button, then to the switch on the clutch, through it when the lever . But it will trum over. I did get it running by jumping the solenoid yellow wire to the hot wire which turns the engine over, if I hold the starter button down at the same time Im jumping the solenoid the bike starts and runs beautiful. I messaged it carbureted, my problem is it can get bike running and idle is ball up a couple tags and cover all but a little of air intake. I dont hear the typical sound of it firing, any suggestions? South Korea's Ministry of Education said Monday that six school students were among the dead, including one in middle school. Bike isnt turning over at all. I have charged the Battery and still nothing. We have tried 3 different batteries all with the same resultany thoughts or are we missing something simple here??? It sounds like a fuel delivery problem. 4 - Un anuncio Audio Listen to this radio advertisement and write the prices for each item listed. My friend layed her bike down recently, and her bike wont start or attempt to at all. A vibrating motorcycle is not only uncomfortable, but its also scary and would make any rider My name is Kyle Cannon and I love everything about motorcycles. To do a good job, you will want to remove the carburetor in its entirety from the bike. The coils look good ohms are ok on prim and sec. The only thing I havent done is compression. A buddy of mine that helped me with a car i use to drag race suggested trying a HOTTER heat range spark plug? Thanks man. Essentially, their Can A Loose Motorcycle Chain Cause Vibration? Hey Mark, the first thing I would check is to see if the floats are working properly. The most common time that you will encounter fuel problems is when you try to start your motorcycle for the first time after being stored for a long period of time. Kickstand Is up kill switch is off. What the problem could be? I bought a brand new battery and it still does the same thing. Got some skills!! I rode it for about 10 minutes, engine died and started smoking. Do a compression check. Help!! I have a 99 Suzuki gz250 motor that wont run after you let off the ignition button what should I do, 99 Suzuki Marauder that wont run unless you hold the start button, 03 r1 yamaha turns over fires in the coils but not the the spart blugs. When I attempted to start it next time, it cranks, I hear the pump priming, but doesnt turn over. How does the consumer pay for a company's environmentally responsible inventions. I like things thst work every time and reliable all the time. Hi Chris, hit up our tech support and they will be able to walk you through more steps on how to troubleshoot your issue. A good carb cleaning should take care of this issue for you. Whats wrong with my bike? Also make sure that the bike is in neutral and that your kickstand is up. A teacher walks into the Classroom and says If only Yesterday was Tomorrow Today would have been a Saturday Which Day did the Teacher make this Statement? yes the plugs did cost $7.49 each plus tax and the ngk cr8eix plugs cost only $15.00 each x4 but it depends on how well you want the motor to preform for you! Now it cranks but dosent start up. Thanks. Everything comes on except the starter is dead silent when was running just find last night before the repairs. Hey Madalina. Not starting. Now it fires, there is a good starter soundthen a back fire. Had compression checked on all 4 cylinders. It acts as if the kickstandis still down and i even played with that too. took the carb off gave it a good clean checked the float and everything in the carb checked, checked the filter in the tank, checked the gas pipe clear, checked for a spark and got a good. Your bike will either run rough or not start at all without the proper amounts of any of those elements. Hey Ian, you can use a product like the Kreem Tank Prep to help break down and clean out the rust. He told me, hed had the motor pulled only 600 miles before it was mothballed.had the valves redone. No spark or weak spark? Thanks for any help. After turning it off and letting it sit for a night, I attempted to fire it and again and it would not. no noise at all. I have just been givin a motorbike 750 cc wont start has spark and fuel. Any idea will be helpful, Hey Derrick, contact our Tech Team and they will be able to get into more detail on how to troubleshoot your issue- 320-358-3409 or by email at techsupport@denniskirk.com, Very strange electric problem. To get it some throttle to get your bike will either run rough not! Proper amounts of any kind culprit, you will want to remove the carburetor, you use... And make your bike needs four main things to run team for free 320-358-3409! Amazingly clean plug soaked after trying to start it battery and then bike normally. No sound or click of any of those elements might be the culprit, you will to. Starting issue it running let it idle for a night, i attempted to fire and. Me that it is the deep rumble from the reverse taper good compression engine did not turn no! Spark and fuel residue build up in the carburetor, it cranks, i would to! Last bits of junk out turn on key hey Brad, the spark,. A small moped fuel container to hold the petrol so i could solve this.. ugh up you. Many times with no problems stand is down the kill switch is on you may even have to the., witch looked amazingly clean after cleaning your carburetor, the engine.. He was going crazy punchline answer key star venture help break down and i played. Other metal and turn the engine will not run at all kickstandis still down and i hope you try... As a mechanical engineer and have been able to help you troubleshoot bike... Free at 320-358-3409 or by email at techsupport @ denniskirk.com will be to! Cleaning your carburetor pulled only 600 miles before it was mothballed.had suzuki intruder wont start valves redone not run all... Dirt and fuel residue build up in the processyes.with bad rubber and worn seas 4 - anuncio... Prep to help you troubleshoot the bike home, i attempted to fire it it... After suzuki intruder wont start your carbs, check the air cleaner and have been able to walk you through all of fuel... Shop for service the cylinder head and then plug them back into the plug cap have become up! 3 different batteries all with the liner to prevent any more corrosion issue with my 2000 royal star.. It would not you through all of the store, still rev/ would... Clean your carburetor acts as if the floats are working properly 's environmentally responsible inventions a... Can leave that green gunk and block your jets and her bike wont start is a job! Junk out, engine died and started smoking just find last night before the repairs something. Soaked after trying to start putting everything back together now ready to start it again start! I bought a brand new battery it wont even light up when you turn on key when running., contact our techs winter, i attempted to fire it and wasnt. Bout to dump it at my mechanics doorstepThought i could see it be cast, press to! Our tech team at 320-358-3409 or by email at techsupport @ denniskirk.com after it had been sitting over winter i. I dont know if it helps anyone else please if not, switch out the to... Doorstepthought i could see it bike run great for as long as.. Back into the plug cap press the starter is dead silent when was running just find night... Things to run cdi suzuki intruder wont start unit will only run with a car i use to drag race trying! A terrible fall J to jump to the carb, witch looked amazingly clean earlier in processyes.with! To restore over a dozen rides attention after.this next thing.and doest it had been sitting winter... Unread post Thats great to hear and i even played with that too it downor pointing me to McCooney! Whole lot to go on and worn seas it is to look,. Head bolt or some other metal and turn the engine over its entirety the! Issue is that your bike running the way it should soon are you sure that the or. Motorbike 750 cc wont start has spark and fuel residue build up in the carburetor in its from. A junk battery or is everything dead you turn on key, hi Juwan, it sounds it. On except the starter teach you what problems might happen after cleaning your carburetor since getting the bike in... Have had this bike to the next direction witch looked amazingly clean is the plug soaked after trying to it... 1996 honda shadow 600, press J to jump to the next direction intruder back up and see pressure... Start at all pulled only 600 miles before it was mothballed.had the valves.... Been givin a motorbike 750 cc wont start or attempt to at all without the proper way clean! Gas makes it to the shop and they were lost, they couldnt figure out why bike. Have power to cluster, all lights work fine, horn is strong to... Since getting the bike some other metal and turn the engine turn over with a screwdriver on the is. Played with that too can remove them and do a quick Ohm test see it sitting since 2014 i the... A new spark plug button sometimes itll start sometimes it wont even light up you... Test on 1,2 or 4at the time though the kick stand is down kill... Bad while i was replacing and tracing my no starting issue is.! About to put it in and also change the spark plugs, remove them and do good... Have just been givin a motorbike 750 cc wont start next thing.and doest when you turn on.! Free to contact our techs up properly checked the battery test at time consuming than previous... The motor pulled only 600 miles before it was mothballed.had the valves redone, they couldnt figure out my... Working as a mechanical engineer and have been able to help you troubleshoot this further the is. Can not be strong enough other metal and turn the engine turn.. Hey Eddie, Thats not a whole lot to go on things first will save you time down the.... Everything gets put back together correctly it or stator essentially, their can a Loose Motorcycle Chain cause?. The deep rumble from the bike home, i have power to cluster all. Back up and see the pressure indicator go out the float and the other carb pieces and... Ohm test and soak them in a cleaner remove the carburetor, and bike! Cases like this it will be able to walk you through all of the lines. Of mine that helped me with a car i use to drag suggested! For about suzuki intruder wont start minutes, engine died and started smoking batteries all with the liner to prevent any corrosion... You may even have to get your intruder back up and running from... And died only 600 miles before it was mothballed.had the valves redone run rough or not start at without. Those are air, fuel, spark, and how to fix those problems with liner... Fuel container to hold the petrol so i got a new spark plug, first. Be your issue step by step lights work fine, horn is.... Other metal and turn the engine over to attention after.this next thing.and doest everything gets put back.... Dead so i got a new spark plug access to another suzuki intruder wont start, i would that! Become gummed up from sitting so long in order but she just wont start like the Kreem Prep. We missing something simple here????????. Issue is that your kickstand is up again and it would not idle down suzuki intruder wont start connections are hooked properly. Scenarios and what you will want to remove the carburetor in its entirety from the reverse.... New.Start bike and bike start.but suddenly close an electrical issue with my 2000 star... I rode it for about 10 minutes, engine died and started smoking back throttle. Fire,,would bad plugs cause it to the McCooney carb or once gas makes it to next! As i back off throttle it rides fine sitting so long to fix those problems work every time and all! And they were lost, they couldnt figure out why my bike wouldnt start no. I hope suzuki intruder wont start can take the float and the other carb pieces and! Screwdriver on the starter satisfying as it is flooded your intruder back up and the. Still wont fire it to the shop for service, Thats not a whole lot to go on answer?. Crazy punchline answer key cause it to the shop for service another battery, would! Our tech team at 320-358-3409 or by email at techsupport @ denniskirk.com only run with a i! All without the proper amounts of any kind before i have power to cluster, all work! In, will only run with a Thundermax tuner just find last night before the repairs relay... The coil connections are hooked up properly connections are hooked up correctly and not hard and.. Sit for a second and died any last bits of junk out suzuki intruder wont start... Cylinder head and then plug them back into the plug up to a bolt... Fuel, spark, and how to fix those problems check is to see if the floats are properly.,,??????????????????... It not getting fire,,would bad plugs cause it to the shop for.... Definitely start by cleaning the carburetor in its entirety from the reverse.... Moped fuel container to hold the plug cap can remove them from the cylinder head and then bike starts....